Aluminum Decking - Appearance Enhanced by Tongue and Groove Decking » The Deck Design And Deck Building Supersite

« « Mahogany Decking - Maintaining Your Waterproof Decking | Timbertech Decking - Wood deck cleaning: » »

Aluminum Decking - Appearance Enhanced by Tongue and Groove Decking

Sunday, March 2nd, 2008 Subscribe To Our Feed

Patio Deck Flooring
Patio Decks Completely ‘Floored’?

Each and every aspect of homes needs to be carefully studied before selecting and incorporating into the homes. These aspects may look minor …..

Finishing the top of you deck for quality, stability, and appearance can be a chore, but the finished look can be enhanced by tongue and groove decking. Done right, it will last a long time, and a smooth surface can be obtained easily.

That decision made, proper preparation is essential to making the finished surface livable and easily maintained. Too many times, tongue and groove decking is installed improperly with nail heads showing, ill-fitting joints, and rotting or cracked edges.

Once the foundation for the deck is installed, go ahead and set the boards to length but don’ t nailed them down just yet. You’ ll want to first paint the groove side of the boards with a primer paint made for outdoor use. Once dry, usually about twenty-four hours if a high quality oil-based paint was used, you can begin to install the tongue and groove decking.

Holes for any nails you need close to the end of the wood should be pre-drilled to prevent cracking. The holes should not be any bigger than the size of the nail, and a slightly smaller hole is preferable.

Patio Tones Deck Coating Gleaming Deck
The decks and patios in homes play an important role in enhancing the outdoors of a home. Thus constructing or renovating patios must be done with a great amount …..

When you start to nail down the tongue and groove decking, go ahead and paint the tongue part of the board with the primer already dried in the groove. While the paint is still wet, you can put the board in place and the wet paint will help form a seal in the joint.

Secure Nailing a Must for Longer Life

Securely nailing tongue and groove decking can be a challenge if you are using an air or electric nail gun. Kneeling on the deck to nail can put the gun in the right position to fully sink the nail, but it will also put you on top of the newly-painted tongue of the deck and create quite a mess.

Standing on the ground to nail will keep you off the wet paint, but you will have to hold the nail gun basically backwards. It’ s a little awkward but easier than having to go back on every nail with a hammer and a counter-sink to properly secure the tongue and groove decking.

Stone Patio Deck Design Stunning Stone
A home can be built using different kinds of materials like wood, concrete, stone etc. the use of each of these materials gives a different look to the home. Each of these have their share of …..

A lot of the time, when using tongue and groove decking you will experience a warped board that doesn’ t fit just right. Especially with pine woods, boards shaped like bananas are not that uncommon. To fit them properly, a large wood clamp can be used as a spreader between the board you are trying to bend into shape and another solid board already in place.

……

Read more here …… Appearance Enhanced by Tongue and Groove Decking

Tags: Procell Decking, Decking Trex, Plastic Decking, Trex Decking